PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 01 of 04
Permatex(R) Hydraulic Jack Oil
80055
1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Product Name: Permatex(R) Hydraulic Jack Oil
Item No.: 80055
Part No.: 78F
Product Type: Hydraulic Fluid
2. COMPOSITION, INFORMATION ON INGREDIENTS
Ingredients CAS No. %
Mineral oil 64742-52-5 95-100
Polymethacrylate dispersion Proprietary 1-3
Rust inhibitor Proprietary 0.1-1
Surfactant Proprietary 0.01-0.1
Ingredients which have exposure limits
Exposure Limits (TWA) ACGIH OSHA OTHER
Ingredients (TLV) (PEL)
Mineral oil 5 mg/m3 mist 5 mg/m3 mist 5 mg/m3 mist
Exposure Limits (STEL) ACGIH OSHA
Ingredients (TLV) (PEL)
Mineral oil 10 mg/m3 mist None
3. HAZARDS IDENTIFICATION
Toxicity: Skin and eye irritant.
Primary Routes of Entry: Skin, ingestion, inhalation
Signs and symptoms
of Exposure: Prolonged exposure may cause dermatitis. Breathing
of mist or vapor may cause irritation of the
pulmonary tract or aspiration pneumonia.
Existing Conditions
Aggravated by Exposure: None known
Literature Referenced Carcinogen
Ingredients Target Organ and Other Health Effects NTP IARC OSHA
Mineral oil IRR NO NO NO
Polymethacrylate dispersion No Data NO NO NO
Rust inhibitor No Data NO NO NO
Surfactant No Data NO NO NO
-------------------------------------------------------------------------------
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 02 of 04
Product Name: Permatex(R) Hydraulic Jack Oil
Item No.: 80055
3. HAZARDS IDENTIFICATION (continued)
Abbreviations
IRR Irritant
4. FIRST AID MEASURES
Ingestion: Do not induce vomiting. Keep individual calm.
Obtain medical attention.
Inhalation: Not likely to occur except as mist. Remove to
fresh air. If symptoms persist, obtain medical
attention.
Skin Contact: Wash with soap and water. If irritation persists,
consult a physician.
Eye Contact: Flush with water for at least fifteen minutes.
Obtain medical attention.
5. FIRE FIGHTING MEASURES
Flash Point: More than 200°F Method: Open cup
Recommended
Extinguishing Agents: Carbon dioxide, foam, dry chemical
Hazardous Products formed
by Fire or Thermal Decomp Irritating organic vapors
Unusual Fire or
Explosion Hazards: None
Explosive Limits:
(% by volume in air)Lower Not available
(% by volume in air)Upper Not available
6. ACCIDENTAL RELEASE MEASURES
Steps to be taken in case
of spill or leak: Contain spill. Soak up in an inert absorbent.
Store in a closed container until disposal.
Clean up residue with soap and water.
7. HANDLING AND STORAGE
Safe Storage: Keep away from flames, sparks, or hot surfaces.
(Contact Loctite Customer Service 1-800-243-4874 for shelf Life information)
Handling: Avoid skin contact. Keep away from eyes. Avoid
prolonged breathing of vapors.
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 03 of 04
Product Name: Permatex(R) Hydraulic Jack Oil
Item No.: 80055
8. EXPOSURE CONTROLS, PERSONAL PROTECTION
Eyes: Safety glasses or goggles.
Skin: Neoprene or plastic gloves.
Ventilation: Sufficient to maintain vapor concentration below
TLV.
See Section 2 for Exposure Limits.
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance: Amber liquid
Odor: Mild petroleum
Boiling Point: More than 500°F
pH: Does not apply
Solubility in Water: Negligible
Specific Gravity 0.905 at 60°F
Volatile Organic Compound
(EPA Method 24) 21.6%
Vapor Pressure: Less than 5 mm
Vapor Density: Not available
Evaporation Rate
(Ether = 1) Not available
10. STABILITY AND REACTIVITY
Stability: Stable
Hazardous Polymerization: Will not occur
Incompatibility: Strong oxidizers.
Conditions to Avoid: Not available
Hazardous Decomposition
Products (non-thermal): None
11. TOXICOLOGICAL INFORMATION
See Section 3.
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended methods of
disposal: Incinerate following EPA and local regulations.
EPA Hazardous Waste
Number NH - Not a RCRA Hazardous Waste Material
PERMATEX INDUSTRIAL CORPORATION 07/02/97
ROCKY HILL, CONNECTICUT 06067
TELEPHONE: (860) 571-5100
MATERIAL SAFETY DATA SHEET Page 04 of 04
Product Name: Permatex(R) Hydraulic Jack Oil
Item No.: 80055
14. TRANSPORTATION INFORMATION
DOT (49 CFR 172)
Domestic Ground Transport
Proper Shipping Name: Unrestricted
Hazard Class or
Division: Unrestricted
Identification Number: None
Marine Pollutant: None
IATA
Proper Shipping Name: Unrestricted
Class or Division: Unrestricted
UN or ID Number: None
15. REGULATORY INFORMATION
CA Proposition 65: WARNING: This product contains chemicals known to
the State of California to cause cancer
and birth defects or other reproductive
harm.
16. OTHER INFORMATION
Estimated NFPA(R) Code:
Health Hazard: 0
Fire Hazard: 1
Reactivity Hazard: 0
Specific Hazard: Does not apply
Estimated HMIS(R) Code:
Health Hazard: 0
Flammability Hazard: 1
Reactivity Hazards: 0
Personal Protection: See Section 8.
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Prepared By: Stephen Repetto
Title: Research Chemist, Health and Safety
Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT 06067
(24hr.) Phone: (860) 571-5100
Revision Date: January 22, 1996 Revision: 0019